News

2022 Ford F-150 Lightning strapped to dyno despite challenges

A 2022 Ford F-150 Lightning has been independently dyno-tested for the primary time. The check, which proved difficult to conduct, confirmed that Ford’s all-electric pickup truck comes near its factory-rated output.

An extended-range mannequin was used within the check, which was performed by the Texas Truck Present with help from dyno producer Dynocom. Ford charges that model at 580 hp and 775 pound-feet of torque, and the dyno confirmed 564.9 hp and 783.5 lb-ft on the wheels. That represents a 3% loss in horsepower from the motors to the wheels, however barely extra torque than the revealed specs.

2022 Ford F-150 Lightning dyno check

Simply getting that outcome was troublesome, Brian Raupe, host of the Texas Truck Present, defined in an e mail to Motor Authority. At 145.5 inches on the hub facilities, the Lightning’s wheelbase exceeded the boundaries of most all-wheel-drive dynos testers had entry to. These are typically used for smaller sports activities automobiles and max out at a 125-inch wheelbase.

With efficiency vehicles, the answer would sometimes be to run in rear-wheel drive on only one set of rollers. However that wasn’t an choice with the dual-motor Lightning. Dynocom ended up modifying one in every of its DC-6000 dynos to accommodate the Lightning’s longer wheelbase. The DC-6000 makes use of a gearbox to synchronize the 2 rollers. That is extra correct than typical belt programs, that are susceptible to stretching, Raupe famous. 

Dyno exams additionally sometimes depend on engine rpm, however that is not a related determine for EVs due to their immediate torque. Dynocom measured wheel pace as a substitute. A ultimate drive ratio can be wanted for calculations, however Ford does not publish one for the Lightning. Utilizing wheel pace and tire peak, testers estimated a ultimate drive of two:1 for every of the Lightning’s motors.

Lastly, the Lightning initially lower energy all the way down to lower than 200 hp round 70 mph, then would ramp again as much as full energy on the way in which to an indicated 107-mph high pace. This was attributable to extreme acceleration with out real-world weight and wind resistance, Raupe stated. Principally, the truck thought it one thing was improper and restricted energy. The workaround was utilizing software program to use added resistance to the dyno rollers, simulating real-world circumstances.

Try the embedded video to see the Lightning’s dyno runs.

Source link

Related Articles

Leave a Reply

Your email address will not be published.

Back to top button